reducing viscosity of crude oil of highly viscous petroleum products reducing the amount of oil sludge and sediments in oil in reservoirs device equipment technology

TRGA
reduced viscosity of crude oil and high viscosity petroleum products.
device and technology.




0. Main theses
:

We can make devices and systems for reducing the viscosity of heavy natural oil and other highly viscous products.
We can also solve two important related tasks -
1. Reduce the amount of solvent that is added to natural oil to reduce its viscosity (see clause 7).
2. Reduce the amount of sediment that forms during the operation of transit oil tanks for collecting and transporting heavy oil.



1. Introduction.

- The topic of crude oil reducing viscosity is extremely relevant for countries that produce heavy oil.
Viscous oil is a problem during production (1), with temporary storage in transit tanks (2) and in transit pipes (3).

- the topic is of great practical importance and any, and even partial, improvement of current technological processes - will bring a huge income.

- many scammers have earned on this topic and a lot of gullible investors have been ruined, a lot of people talk about it,
but we will show you our effects to deserve your attention.

- Is it possible to reduce the viscosity of crude oil (or other heavy oil products) using the hardware method, without using additives or thinners or minimizing their amount? The answer is yes!


2. Methods solutions.

To reduce the viscosity of natural oil, viscous petroleum products and / or high-molecular substances, there are only four standard ways:

1. Increasing the temperature (requires an enormous amount of energy and its presence or energy infrastructure. In some cases it is not possible in principle).
2. Mixing with a low viscosity fluid
(viscosity averaging) or with a solvent (viscosity averaging with modification of the properties of the initial viscous fluid).
3. Mechanical
(non-reagent) processing without the use of additives and solvents.
4. Various combinations of the first three points.


3. Our practical experience.

In the old days, we had a large number of effects when our TRGA device reduced the viscosity of fuel oil, oil, high-molecular compounds, but then it was not our priority task. Recall our pasе results that you appreciated the reliability of our technical solution.

reduction crude oil viscosity  before
reduction crude oil viscosity  after
1. Light paraffin oil, Ukraine. Processing on the module TRGA, before and after processing. At the same temperature, the viscosity of the treated oil sample ( right ) - considerably lower. Analyzes have not been done.
reduction crude oil viscosity high viscosity petroleum oil products boiler marine fuel viscosity reduction
3. Ship fuel IFO180, Slovenia, Croatia. year 2012. Processing on the module TRGA, before and after processing. Analyzes pivot table.

Comparative analyzes from Croatia.
Comparative analyzes from Slovenia.
Investigation of processed ship fuel, Croatia.
Pilot project (page 16) the instantaneous changes in the fuel to be treated.


The result is short:

- 2 weeks after the treatment of ship fuel, the viscosity was 15% lower than the initial one.
- 3 weeks after the treatment of ship fuel, the viscosity was less than the initial by 10%.
- lowering the pour point by 2-6 degrees.
- additives and diluents were not used.

reducing viscosity amount oil sludge sediments in oil reservoirs
4. Oil sludge open storage, Russia. 2013. Processing on the module TRGA, before and after processing. At the same temperature, the viscosity of the treated sledge sample (right) - considerably lower. Analyzes have not been done.

Film. More.

The result is short:
- double reduction of viscosity,, additives and diluents are not used.

boiler marine fuel oil viscosity reduction
boiler marine fuel oil viscosity reduction
5. Boiler fuel, fuel oil number 6, (M100) Vladivostok, 2014 and 2012.
On the left is the communal boiler room and the second link (right) - is the drying furnace of the asphalt plant.

The type of fuel is standard M-100 fuel oil (fuel oil number 6 in the American classification).

The result is short: in both cases, the viscosity of the treated fuel has decreased so much that it has become possible to use nozzles with half the flow area. Additives and thinners were not used.
reducing viscosity amount oil sludge sediments in oil reservoirs device equipment technology
6. Oil sludge open long-term storage. Russia, 2016. Analyzes have not been done. Film. More.

Film.
Left Bank - starting oil with a high paraffin content, melting point 55 degrees.
Bank middle - original oil after processing with TRGA homogenizer.
Right Bank - a standard fuel oil M-100. (fuel oil number 6 in the American classification)

Air and fuel oil temperature +20 degrees Celsius.
Time - 5 days after the treatment of fuel oil.

The result is short:
- 5 days after treatment, without the use of additives and solvents, the viscosity was less than the initial two times ... No additives or thinners were used.

viscosity high viscosity petroleum oil products boiler marine fuel oil viscosity reduction

This is an important result for the technology
of mixing natural heavy oil and solvent.
7. Boiler fuel, fuel oil number 6, Philippines, 2017. Analyzes. Article.

Boiler fuel of medium viscosity and a mixture of boiler fuel and 10% diesel fuel.

The result is short:
- viscosity of low-viscosity boiler fuel, after treatment without additives and solvents - decreased by 17.48%.
- the viscosity of the mixture (fuel oil + 10% of diesel fuel as diluent) decreased by 90%.

molasses reduced viscosity mixing molasses improved properties of highly viscous molasses

this is an important result
for increasing the efficiency of the production of alcohol


8. High viscosity molasses and comparison of a mixture of different molasses samples 2017 and 2018. Ukraine.

The result is short:

We treated mixture of coarse and fine molasses (viscosity about 2000 centistokes) and this mixture was less viscosity (approximately twice) than the best of the starting components. Film.

After 6 months, the viscosity of the processed mixture remained significantly lower than the initial. Link. Film.

Additives and solvents were not used.

Below, this film once again, enjoy a huge difference in viscosity, which was achieved and preserved 6 months after processing the highly viscous product through a TRGA homogenizer.

And when we put all our results into the system ... we realized that our device and our methods can be practical use for the task of reducing the viscosity of petroleum products and other highly viscous substances. We understood that "we realy can ", and our equipment is more reliable than others (some samples work 10 years) and require less energy than other analogues.
 
9. We understood that we can and our equipment is more reliable than the others (up to 10 years trouble-free) and require less energy less than other analogues.

The result is short: The test in the certified laboratory GAZPROMNEFT which has the entire world collection of certificates. Raw materials - heavy natural oil. The initial viscosity is 197.8 centipoise. Oil viscosity after a single treatment (without additives and solvents) - 156 - 159 centipauses. The same processed samples after 15 days - 165 - 167 centipauses. The official report is here.
reduction crude oil viscosity high viscosity petroleum oil products boiler marine fuel oil viscosity reduction reducing viscosity amount oil sludge sediments in oil reservoirs device equipment technology


4. Proposed solution.

The history of the results and the last test convincingly show that our equipment can be an important component of devices and systems for the task of reducing the viscosity of heavy natural oil and other highly viscous products, including those prone to sticking. We can also solve two important related tasks -

1. Reduce the amount of solvent that is added to natural oil to reduce its viscosity (see clause 7).
2. Reduce the amount of sediment that forms during the operation of transit oil tanks for collecting and transporting heavy oil. Short presentation here.

This is real and reliable information. Want to be our partner? We are pleased - this is a good investment. Every year, the viscosity of the extracted crude oil increases and the cost of its transportation grows.

 
 


Additional information
full version on the
www.afuelsystems.com

 
All rights reserved
2006-2019
home
page
Google
www.afuelsystems.com - Технологии и оборудование для обработки и экономии топлива (бензин, дизельное топливо, мазут, коксохим ). Кавитация, диспергация, эмульгирование, топливные и другие эмульсии. Экология
eXTReMe Tracker